Does the Aspirin method cure the headache associated with this?
LOL
Bob Winslade
1966-1600 Missy (finally working on her again!)
1967-1600 Bender
----- Original Message -----
From: "Pat Horne" <roadsters@hornesystemstx.com>
To: "Roel Hammerschlag" <sky@drizzle.com>
Cc: <datsun-roadsters@autox.team.net>
Sent: Thursday, September 13, 2007 8:04 PM
Subject: Re: [Roadsters] filling up a '70 1600 cooling system
> Roel,
>
> There are a three ways to make things easier.
>
> One is to drill a small hole in the thermostat flange to allow air to
> escape from below the thermostat. A 1/8" will do the trick.
>
> Another is to open the thermostat by pushing a screw driver or rod onto
> the top of the thermostat, opening it up to let the air out.
>
> Finally, if the thermostat is out of the engine, open the thermostat and
> insert an aspirin tablet to hold it open. When the water level gets the
> aspirin wet it will dissolve. The trick is to keep the water from
> getting to the aspirin from the top.
>
> Good luck.
>
> Peace,
> Pat
>
> Thusly spake Roel Hammerschlag:
>> Hi folks,
>>
>> I have a 1970 1600. At the risk of embarrassing myself:
>>
>> Every time I drain the cooling system I have the most incredibly
>> difficult time filling it back up. Because the thermostat's closed,
>> it's virtually impossible to get the block filled with water. The very
>> suboptimal solution I've come up with is to run the engine half dry
>> until the thermostat opens despite not being submerged (the temp gauge
>> usually reads over 260 before this happens) and then sloooowwwwwly
>> adding more fluid into the running engine so as not to crack anything.
>> There's GOT to be a better way. Can someone help me out?
>>
>> - Roel
>>
>> P.S. I also don't really understand how that reservoir tank on the side
>> works, either. Maybe this is part of my problem. I try to keep it
>> roughly half full like the original manual says.
>> ________________________________________
>>
>> roadsters@hornesystemstx.com
>>
>> Datsun-roadsters mailing list
>>
>> http://www.team.net/archive
>>
>> http://autox.team.net/mailman/listinfo/datsun-roadsters
>>
>>
>>
>
>
> --
> Pat Horne, Owner, Horne Systems
> (512) 797-7501 Voice 5026 FM 2001
> Pat@HorneSystemsTx.com Lockhart, TX 78644-4443
> www.hornesystemstx.com
> -- We support Habitat for Humanity - a hand UP, not a hand OUT --
> ________________________________________
>
> bubwin@mts.net
>
> Datsun-roadsters mailing list
>
> http://www.team.net/archive
>
> http://autox.team.net/mailman/listinfo/datsun-roadsters
________________________________________
Datsun-roadsters mailing list
http://www.team.net/archive
http://autox.team.net/mailman/listinfo/datsun-roadsters
|